Fixed electric motor on window now security system wont work and car wont start
SOURCE: oil in water resovour vw 2002 passat
This is probably a head gasket problem and not an oil cooler problem.
The oil cooler is fairly easy to test.
Remove the cooler from the engine but do not disconnect cooling lines and then pressurize the cooling system. You can use a radiator test tool to put pressure on the cooling system and look for leaks. If it leaks, replace it.
You may also be able to bypass the oil cooler altogether if it leaks.
The head gasket is another story.
Get a 1/4" pipe to spark plug fitting and put a male air coupling fitting in it.
Then you can charge the cylinders with air from your compressor.
Make sure each cylinder that you test is at top dead center so that the valves are closed.
If air bubbles into your coolant, you found your problem.
If air leaks out your intake you have a bad intake valve
If air leaks out your exhaust you have a bad exhaust valve etc.
If you find this useful, please take the time to rate it.
Tim
SOURCE: Resetting the service now light on VW
hold down wrench button on right of steering wheel,turn on ignition, then push the min button on the left.then igniton off and it should be reset
bealz104
SOURCE: Tank Flap - Electric : Will not open
I have a 2003 passat with the same problem, i noticed that the little nipple on the left hand side that releases to open the flap was inside the hole its self .
The book tells you nothing regarding this and i couldnt find on the internet how to get to it other than taking off the guard above the wheel and getting it that way.
I went out today and took the carpet away from the side of the boot closest to where the flap was.
I then saw the flap solenoid which had 2 little wires and a rod attached. The solenoid or motor as i call it was held on by two little bolts which i took off and had look at it but to be honest i had no idea what so ever as to what it should look like or do ha ha.
The rod that is attcahed to solenoid is the rod that comes through the hole to keep flap closed or to release it. I pushed the rod and couldnt see hyow it would release and hold so i took the rod off the motor and pushed the end of the motor that the hook was attached to and it made a noise i hadnt heard before but it was one of those good noises lol i didnt have any wd40 to spray on it as i used this for something else so i used some vaseline to rub on the end where the hooked rod goes onto and put the rod back on.
I then put the bit that comes through to lock or release into position and then bolted solenoid back in place and connected the wire again went to check thinking i am not that lucky and hey presto all mine needed was bit of lube lol and without the dirt and hassle of taking of the guard above the wheel.
Hope this helps as there is no way of opening this manually as i was told this monday when i called vw.
Shell
SOURCE: VW Passat 2006 service now
2 options depending on your displays .
Press and hold the service wrench button with the ignition off. While still holding the button, turn your ignition to "on" (but don't start the car). Press the Min clock button and then release the wrench button.
With key off press and hold the 0.0 button on the cluster. With your other hand turn the key to the on position , while still holding 0.0 button, press the minute button for 1 second and you will see the service reset.
cheers
SOURCE: Fuse box layout for a 2002 VW Cabrio
Fuse colors
30 A-green25 A-white20 A-yellow15 A-blue10 A-red7,5 A-brown5 A-beige3 A-violetFuse locations
Fuse Location
Fuse locations for options not shown can be found in the corresponding wiring diagrams.
Amp.
1-Headlight, Low Beam, Left (56b)102-Headlight, Low Beam, Right (56b)103-License Plate Lights (58) 104-Rear Window Wiper And Washer System155-Windshield Wiper/Washer156-Fresh Air Blower, A/C (X)207-Tail Lights, Right (58R)108-Tail Lights, Left (58L)109-Rear Window Defogger2010-Fog Lights1511-Headlight, High Beam, Left (56a)1012-Headlight, High Beam, Right (56a)1013-Horn (15)1014-Back-Up Lights1015-Engine Electronics (15)1016-Power Sunroof, Front Map/Reading Light1517-Emergency Flashers (15)1018-Fuel Pump (FP), Heated Oxygen Sensor (HO2S) Control Module2019-Coolant Fan, A/C Relay (30)3020-Brake Lights (30)1021-Interior Lights, Clock, Luggage Compartment Light (30)1522-Cigarette Lighter, Radio, Luggage Compartment Release10Separate Fuses
(Located above the relays)
-Fuse for ABS hydraulic pump relay30-Fuse for ABS main relay30-Fuse for A/C30-Fuse for power windows20-Fuse for cruise control5-Fuse for cigarette lighter15In the engine compartment above the brake booster:
-Glow plugs50
4,103 views
Usually answered in minutes!
×