2006 Chevrolet Aveo LS - Answered Questions & Fixed issues

Have your dealer repair it , shorting a wire can deploy the air bag and cause many dollars worth of damage, not worth the risk.

There are two things that generally cause a battery warning after an alternator replacement. The most common is a loose connection either with the control plug (aka “relay” plug-in), charging line connection, or the ground. The other is a blown fuse or defective connector or relay, which could have been broken or shorted when the alternator was installed or on the first start-up after its installation.
You can check that the alternator is supplying enough power by starting the car and disconnecting the battery. If the car dies, the alternator isn't working properly (or a wiring/relay/fuse issue).

Was the right oil used? Happening before oil change? Have the computer scanned & ck for any codes. Poss reacting to cooling system. Cam & crank sensors etc.

google it

on the web: images for 2006 Chevrolet Aveo LS oil pump location.

EBCM has detected an open, short to ground, or a short to battery on the left rear wheel speed circuit.

just check the Left Rear Wheel Speed Sensor Circuit for any problems.

clean injectors air filter

clean injectors/ feul filters

take a screw driver and depress the piston by prying the brake pad against the rotor. Then take the caliber off and replce pads , then simply re-do step and reassemble caliber.The only problem you may run into is the caliber has to be pushed and turned at the same time. if so you will need a special tool to do so.

Condensers rarely clog. What it could be is that when it was recharged, air got into the system and may have to be bled out and fill the rest of the way with freon.

Both codes are for the throttle position sensor - - sometimes the computer is not getting any voltage from the sensor. Could be a sensor problem or a wiring or connector problem.

SCHEMO YOUR 1.5l IF USA THAT IS. IF SPARK IS DEAD,YOU ARE BARKING UP THE WRONG TREE !

Please check your clutch

dealer need vin and proof of ownership

Imobiliser is switched on. Switch it off and try again.

some of the spares have a tps check them if no sensor then one of the sensors are failing

Which engine does yours have ? Figure 1: Single Cooling Fan (1.2L) Figure 2: Single Cooling Fan - 1.4L SOHC, 1.5L Figure 3: Dual Cooling Fan - 1.4L DOHC, 1.6L The first two have two relays in the under hood fuse box ,the last one uses three relays . all located in the under hood fuse box

All listed here https://www.aveoforum.com/forum/f82/2009-aveo-1-6-head-bolt-torque-specs-21716/ ..

What is the torque setting for chevrolet aveo 2009