Suzuki Motorcycles - Recent Questions, Troubleshooting & Support


It is highly unlikely the gearbox will mount in a 2003 frame without modifications. The crankcase part number for the '94 is 43860. The '03 number is 36890. Nine years is a wide span and many changes have taken place. Sorry.

2003 Suzuki RM... | Answered 1 hour ago


How many wires have you got ........

Suzuki... | Answered 11 hours ago


My manual says 20w/40

1981 Suzuki TS... | Answered on Jan 17, 2019


Could have a dirty injector or fuel filter

Suzuki... | Answered on Jan 12, 2019


Fuel starvation, clean the carb and check its not blocked jets.

2005 Suzuki... | Answered on Jan 09, 2019


Check the gear lever isnt stiff or seized.

2000 Suzuki GZ... | Answered on Jan 09, 2019


The same problem with my intruder. Make sure the battery is good. I mean really good. Good amps and voltage. I replaced mine and haven't had a problem since. Also make sure that the plug gap is right on both plugs. Replace and gap the plugs if need be. Check to make sure that the plug wires at the plugs are inserted as they should be . A lot of times when you pull the plug wires from the plugs they come loose. They screw onto the insulator. One day I was riding and lost power to one cylinder and reached down and grabbed the plug wire and got a jolt. I screwed the plug insulator back on and off I went. Make sure that the plug wires arn't grounding out to the frame at any point. If so replace the plug wires. This was another problem I found. Good luck and Ride Safe. David.

1994 Suzuki VS... | Answered on Jan 08, 2019


Drain any old gas out of the tank and carburetor then clean the carburetor and try again. Could just be dirty fuel.

Suzuki... | Answered on Jan 07, 2019


follow the red /live wire from the battery its bolted to the relay.

Suzuki... | Answered on Jan 06, 2019


Remove the round cover on the side on the engine/trans case.

Suzuki... | Answered on Jan 04, 2019


Remove spark plug and put 1 tbl spoon of gas into cylinder and replace plug - if it starts and runs for a couple of seconds you have a fuel delivery problem. Remove and clean carburetor.

Suzuki... | Answered on Jan 04, 2019


Gas probly gittn old dont keep in tank ovr threemonths. Its gumming up carb. Buy a clymer manual for complete upkeep

Suzuki... | Answered on Jan 03, 2019


Depends on the overall length of the drive shaft and where the CV joints are. I would think that this would not be a good part sub.

Suzuki... | Answered on Jan 02, 2019


Download a service manual. One source is https://www.manualslib.com/. Another option is to join a forum of Katana owners and ask them for a wiring diagram.
Good luck

Suzuki GSX 600 F... | Answered on Jan 02, 2019


Try downloading the owners manual from https://www.manualslib.com/. They also have the service manual, but hopefully the owners manual will be sufficient. Another option is to find a forum that caters to your bike and communicate with others that own that same model.

Hope you get squared away before the next warm day for riding.

Suzuki... | Answered on Jan 02, 2019


bad bulb? connector unplugged??

Suzuki... | Answered on Jan 01, 2019

Not finding what you are looking for?
Suzuki Logo

20,136 questions posted

Ask a Question

Usually answered in minutes!

Popular Products

Top Suzuki Experts

Marvin
Marvin

Level 3 Expert

83850 Answers

Arnie Burke
Arnie Burke

Level 3 Expert

5742 Answers

Steve Banks

Level 2 Expert

232 Answers

Are you a Suzuki Expert? Answer questions, earn points and help others

Answer questions

Manuals & User Guides

Loading...