20 Most Recent
1993 kawasaki ZXR 400 Questions & Answers
Where to put the water in a Kawasaki ZXR 400 1994
The is a reservoir tank mounted under the fuel tank on the left hand side of the bike.Notes:1. always use 50:50 water/anti-freeze2. don't fill tank past the max line (excess coolant will get dump out the bottom of the bike when hot, and coolant of slippery ;)3. If loosing coolant, find out why. Damaged hose, blown head gasket or stuffed thermostat are like causes.
No power in my bike
Try refittin the old cdi box. If it works then the new cdi box may be dead.
Adjusting time chain tension
Its possible your tensioner is worn out , this could be detrimental to your engine.
Best advise would be order new unit from Cradleys Kawasaki UK and get a qualified bike mechanic to fit.
''how to replace starter in 1993 jet ski''
Unbolt the electronics box (swing out of the way), take off the box mount plate, and remove the exhaust upper manifold and expansion chamber. This should give you good access to the starter.
Zxr 400 not running properly after being de-restricted
Did you reconnect the vaccum hose on the right hand side of the airbox? As this needs to be reconnected.
Also on some models the two holes on top of the airbox that give you acccess to the 10mm bolts need to be taped over.
The muffled noise you refer to usually happens sometime after 7-9k rpm if the the above 2 suggestions are not actioned
Just wondering if you know how many kilometers you
Every rider and ride is different. It depends on the rider and the type of riding you are doing. High speed riding reduces your range. If it needs tuned up you get fewer kms per tank. If you are hammering it you will get fewer miles, etc.
Where is the timing/cam chain tensioner located on
On the right hand side of the engine, inside the cylinder head. To look at the assembly. g
o to the site below where you can see a parts diagram for your specific bike. You will select the actual brand, year, model, etc., once you go to the site. Part numbers and prices are also shown. You can order parts from this site. In the event no price is shown on a particular part and/or the notation "Not Available" is in the description, the part is not in stock. www.babbittsonline.com/pages/parts/viewbybrandand/parts.aspx
I have a zxr400 with a flatspot between 4@6
Bent needles can cause horrible throttle response. Start by installing a new needle that way you know its not the problem. If your carbs have rubber diaphrams make sure they arent ripped.
Headlight will not work.
also check the box that control the light. this es the one that does no let the light come on until gets the signal after pressing the starter
I have a 2004 Kawasaki
Sounds like a bad starter without knowing what sounds it made when you turned it over etc. if it did absolutely nothing when you tried to start it but started when jumped via solenoid it’s either wiring between the button and starter or wiring between the solenoid and starter itself
Not finding what you are looking for?