20 Most Recent 2002 KTM LC4 625 Sc - Page 6 Questions & Answers

install a new clutch. make sure chain is properly aligned and lubricated.

check the fuel pump fuse, if getting power then replace fuel pump.

wot about your gear selector ??

remove the chain and check all links are free , check the rear wheel bearings are spinning free and not notchi ! check condition of sprockets teeth not worn !

Main fuse is blown, its under the seat on the + battery wire.

Check rear wheel bearings. Be sure the chain is adjusted and lubricated properly.

Waren clutch and or low oil check oil with engine at running temp also check for metal shavings in your clutch oil

Had great luck with Shorai but you will pay for it.

Clean carburetor idle jet and idle circuit.

94 - 96 only!

Drain the entire system and back-bleed it from the slave cylinder up with a syringe.

If the bolts are spinning you will have to drill off the bolt heads and extract the threads from the base inserts. Replace the petcock base o-ring, epoxy the base nuts into the tank body, install petcock. Or replace tank and valve. It's a choice of time or money.

Carburetor issue. Running to rich, water in carb and tank, or filthy air filter

The ring is too keep the pipe from damaging the cylinder. The o-ring on the pipe is what seals it from leaking.

You must keep the fuel tank at least half full

buy one from your dealer.

get yourself a workshop manual to do this properly

No the starter relay is seperate ! check all fuses and ignition system connections !

rewinding a stator is not difficult, find the right wire, better is square wire, as the heat conductance is better. If you select the same diameter you get automatically approximately the same amount of windings as the original. The sell the wire on Amazon and other places, Bing is your friend.

have you got a spark and is fuel getting to the spark plug ? check these and you might have your answer ! P...