20 Most Recent 2007 Hero Honda Passion Plus Questions & Answers

check throttle cable

before putting 3k first replace the clutch cable. due to aging and deterioration clutch cable become rigid also friction increases. so, the contact of clutch plate is not good. and engine makes sound and you fill 1 gear engine sound up to 4th gear.

too many variables to just find one answer. what condition? including shipping? etc

ramesh. for 3k you probably can get a rebuilt engine which will give you much longer than 30km life. Look into it.

get your clutch plate checked or adjust clutch play

black smoke means to much fuel in the combustion chamber, the black smoke is the excess fuel that not get burned on the compression stroke, adjust the air/fuel mixture, dial fuel back lil by lil til no more smoke

no. it is a gear box design

take the dirt out of the tank . run it till its about empty, or will barely run. Cut the gas off to the engine and run it dry. Take the tank off and turn it upside down and drain it. Put just a tint bit of fuel in the tank, cap itt off, shake it, and drain it again until the fuel comes out clean without dirt. Look inside the tank with a flash light (not matches, lol) and see if it is rusted. if it is rusted you will have to fill it with penetrating oil and shake it every few hours for a few days to eat up the rust, then rinse it with fuel, and try it on the scooty again

Who's TNT?.. it's a fireworks stand where I live..??

remove carb, drain fuel leave for a few hours, and heat the screw, use pliers to gently remove.