2005 ION: I have a 2005 Saturan Ion, the Power Steering lite...

SOURCE: where is 2003 saturn ion thermostat?

FACEING the ENGINE It is At TOP RIGHT SIDE Close to Master Cylinder takes About 1 hour to Replace Have Fun its a EASY One
Please Dont forget to RATE ME Thank You

1. Drain the cooling system.
2. Remove the bolts that secure the thermostat housing to the water pump feed pipe.

1. Remove the thermostat and retaining sleeve, noting the orientation for installation.

1. Install the feed pipe that connects the thermostat housing to the water pump.Notice: Refer to Fastener Notice in Service Precautions.
   
   
   1. Install the bolt that secures the water pump feed pipe.
   • Tighten the bolt to 10 Nm (18 inch lbs.) .
   1. Fill the cooling system.

SOURCE: power steering fuse, where is it?

under the hood it is a square fuse on the drivers side

Ned C Cook

• 3433 Answers
• Posted on Jun 08, 2009

SOURCE: power steering light on, light that looks like engine on

ck your drive belt. and fluid levels

SOURCE: Power Steering

Has anyone gave Saturn any hard time over this power steering issue yet? Looks to me like this is a very WELL KNOWN problem for Saturn's but nothing's been done to solve it. Even newer Saturns have this problem, especially just when the car's out of the lousy warranty that we have. Someone's got to take action, may be a sour law suit would do the job.

SOURCE: change brake pads on saturn ion 2004

my car was stollen and used in a robbery and high speed chase.the strip was used to flatten the front tires and he still ran 1mile and a half on them flat.but my insurence payed to get it fixed after my 500.00 deduct.when i got it back i have damage to the front finder they didnt fix.and after i traveld 500 miles to come back home i have a bad noise in front when i had the oil changed i had him check it and he said something had gotten into the brake shoe pasanger side and chued it up now im afaried to drive it and dont have the money now to fix it is this maybe from all that went on with it he ran across a yard and colbert i was told that its hard to get stones in the brakes to do that kind of damege.should i go back to insurance co.i had asked them to make sure they checked out good now im in another state