At Fixya.com, our trusted experts are meticulously vetted and possess extensive experience in their respective fields. Backed by a community of knowledgeable professionals, our platform ensures that the solutions provided are thoroughly researched and validated.
- If you need clarification, ask it in the comment box above.
- Better answers use proper spelling and grammar.
- Provide details, support with references or personal experience.
Tell us some more! Your answer needs to include more details to help people.You can't post answers that contain an email address.Please enter a valid email address.The email address entered is already associated to an account.Login to postPlease use English characters only.
Tip: The max point reward for answering a question is 15.
I would retrace your steps checking for any loose or unconnected wires etc , are you sure the original problem was with the steering motor as you say it still wont work
The system can be scanned for faults, in the is case you need that test performed. The pump only runs when the computer control unit commands it to run it is on demand, this information comes from sensors in the system..
dear . if warring light coming , some time low battery need re program steering ,you need to drive up to 80/k/h then stop
complete turn to right ,complete turn to left ,W.S off and ON
if coming red color warning.check fuses / wiring to steering motor
remove and re fix
Blower MotorRemoval & InstallationTo Remove: WARNING On vehicles equipped with airbags, disable the airbag system before attempting any steering wheel, steering column, or instrument panel component diagnosis or service. Disconnect and isolate the battery negative (ground) cable, wait two minutes for the airbag system capacitor to discharge before performing further diagnosis or service. This is the only certain procedure for disabling the airbag system. Failure to take the proper precautions could result in an accidental airbag deployment and possible vehicle damage and personal injury.
Negative Battery Cable Remote Terminal
Remove or disconnect the following:
The negative battery cable remote terminal from the remote battery post
The lower right under panel duct
The blower motor connector from the blower motor resistor block/power module
The blower motor wiring grommet
squeeze and push the grommet through the blower motor housing cover
The blower motor housing cover
The blower motor retaining screws
The blower motor by lowering from housing
To Install:
Install or connect the following:
The blower motor in the HVAC housing and tighten the mounting screws
Torque to: 20 inch. lbs. (2.2 Nm)
The blower motor housing cover
The blower motor wiring grommet in the blower motor housing cover
The blower motor harness connector to the blower motor resistor block/power module
The lower right under panel duct
The negative battery cable remote terminal to the remote battery post
THis unit uses an electric motor for the Power Steering
It is located under the dash on the steering column. Remove the two bolts and unplug the wires...
You will have to remove the trime under the Steering column and the panel left end of the dash. Cost of the motor is $169.00 from the Saturn Dealership.
REPLACE THE POSITIVE BATTERY CABLE.BESURE TO BUY SOME FLEXIBLE WIRE CONDUIT.PROTECT WIRE FROM RUBBING CAUSING SHORT.ALSO REPLACE NEGATIVE BATTERY CABLE.DUE TO YOUR CAR BEING PCM CONTROL BY DISCONNECTING NEGATIVE BATTERY CABLE WILL CAUSE STARTING PROBLEMS AND STEERING PROBLEMS WITH NEWER CARS WITH ELECTRIC POWER STEERING.LET VOLKSWAGON DEALER REPLACE CABLES AND STARTER.
I had to fit second solenoid and took the positive feed from the carb. slow
running solenoid. The single earth wire from the power steering pump was
connected to the negative feed of the solenoid. The vacuum pipes were connected
to the AC actuator in parallel
×