Saturn Ion Complete Workshop Service Repair Manual 2003 2004 2005 2006 2007
for the easy solution download the pdf file
SOURCE: engine misfiring/fuel coming out exhaust
Sounds like you may need to inspect and replace your fuel line from front to rear. no other reason for your problem.
SOURCE: saturn ion,sometimes wont start
The problem is in the ignition - the grease gets thick in the cold and doent turn quite right the first time. everything turns on, but the anti theft system thinks you have the wrong key so shuts off pwer to the starter. it takes 8-10 mintues to reset. That is why it normally starts when you come back later. I have had the same problem and done tons of reseach. Right now my temp solution has been a small heater and an extention cord. I keep it plugged in over night on a medium setting - just enough to keep the inside temp above freezing. I am also researching remote starts because saturn dealership charges $250 to replace the ignition, and a remote start will run about $300. Saturn wont do a recall because they feel it is not a safety hazard. I say that is bull. Good luck!
SOURCE: strong gas smell coming from my cobalt at all times
Look in the back of the car. The fuel pump lines like to break. You will not be able to see them, but you will smell and see that the fuel tank is wet. Call your local dealership, have you vin # and milage, ask them if it's covered by warrenty.
SOURCE: saturn ion,sometimes wont start
There is a guide on this site that tells you how to fix the passlock problem
http://moontaj.com/passlock
SOURCE: While idling, or sitting in park the car shakes
car needs a tune up plus it sounds like the moter mounts could be broke is why the car is shaking
114 views
Usually answered in minutes!
×